SB1909 94TH GENERAL ASSEMBLY

LRB094 09267 RSP 39503 b

94TH GENERAL ASSEMBLY
State of Illinois
2005 and 2006
SB1909

Introduced 2/25/2005, by Sen. William R. Haine

SYNOPSIS AS INTRODUCED:

415 ILCS 5/3.135

was 415 ILCS 5/3.94

Amends the Environmental Protection Act. Includes additional materials within the definition of "coal combustion by-product" (CCB). Provides that, in certain circumstances, the EPA must (instead of "may") make written beneficial use determinations that coal-combustion waste is a CCB. Sets forth the procedures for the application for and approval and renewal of a beneficial use determination. Provides that CCB for which a beneficial use determination is approved shall be considered CCB for as long as it is used in accordance with the approval and any conditions of the approval.

FISCAL NOTE ACT MAY APPLY

A BILL FOR

AN ACT concerning safety.

Be it enacted by the People of the State of Illinois, represented in the General Assembly:

Section 5. The Environmental Protection Act is amended by changing Sections 3.135 and 39 and by adding Section 9.14 as follows:

(415 ILCS 5/3.135) (was 415 ILCS 5/3.94)

Sec. 3.135. Coal combustion by-product; CCB.

(a) "Coal combustion by-product" (CCB) means coal combustion waste when used beneficially in for any of the following ways purposes:

(1) The extraction or recovery of material compounds contained within CCB.

(2) The use of CCB as a raw ingredient or mineral filler in the manufacture of the following commercial products: cement; concrete and concrete mortars; cementious concrete products including block, pipe and precast/prestressed components; asphalt or cementious cement based roofing products shingles; plastic products including pipes and fittings; paints and metal alloys; kiln fired products including bricks, blocks, and tiles; abrasive media; gypsum wallboard; asphaltic concrete, or asphalt based paving material.

(3) CCB used (A) in accordance conformance with the Illinois Department of Transportation ("IDOT") standard specifications and subsection (a-5) of this Section or (B) and under the approval of the Department of Transportation for IDOT projects.

(4) Bottom ash used as antiskid material, athletic tracks, or foot paths.

(5) Use as a substitute for lime (CaO and MgO) in the lime stabilization or modification of soils providing the CCB meets the IDOT Illinois Department of Transportation ("IDOT") specifications for soil modifiers byproduct limes.

(6) CCB used as a functionally equivalent substitute for agricultural lime as a soil conditioner.

(7) Bottom ash used in non-IDOT pavement sub-base or base, pipe bedding, or foundation backfill.

(8) Structural fill, when used in an engineered application or combined with cement, sand, or water to produce a controlled strength fill material and covered with 12 inches of soil unless infiltration is prevented by the material itself or other cover material.

(9) Mine subsidence, mine fire control, mine sealing, and mine reclamation.

(a-5) (10) Except to the extent that the uses are otherwise authorized by law without such restrictions, the uses specified in items (a)(3)(A) and (a)(7) through (a)(9) shall be subject to the following conditions:

(A) CCB shall not have been mixed with hazardous waste prior to use. ;

(B) CCB shall not exceed Class I Groundwater Standards for the following parameters metals when tested utilizing test method ASTM D3987-85: arsenic, barium, boron, cadmium, antimony, beryllium, chloride, chromium, cobalt, copper, iron, lead, manganese, mercury, nickel, selenium, silver, sulfate, thallium, phenol, and zinc. The sample or samples tested shall be representative of the CCB being considered for use. ;

(C) Unless otherwise exempted, users of CCB for the purposes described in items (a)(3)(A) and (a)(7) through (a)(9) of this Section shall provide notification to the Agency for each project utilizing CCB documenting the quantity of CCB utilized and certification of compliance with conditions (A) and (B) of this subsection. Notification shall not be required for users of CCB for purposes described in items (a)(1), (a)(2), (a)(3)(B), and (a)(4) through (a)(6) of this Section, or as required specifically under a beneficial use determination as provided under this Section, or pavement base, parking lot base, or building base projects utilizing less than 10,000 tons, flowable fill/grout projects utilizing less than 1,000 cubic yards or other applications utilizing less than 100 tons. ;

(D) Fly ash shall be managed applied in a manner that minimizes the generation of airborne particles and dust using techniques such as moisture conditioning, granulating, inground application, or other demonstrated method. ; and

(E) CCB is not to be accumulated speculatively. CCB is not accumulated speculatively if during the calendar year, the CCB used is equal to 75% of the CCB by weight or volume accumulated at the beginning of the period.

(F) CCB shall include any prescribed mixture of fly ash, bottom ash, boiler slag, flue gas desulfurization scrubber sludge, fluidized bed combustion ash, and stoker boiler ash and shall be tested as intended for use.

(b) To encourage and promote the utilization of CCB in productive and beneficial applications, upon request by the applicant, the Agency shall may make a written beneficial use determination determination that coal-combustion waste is CCB when used in a manner other than those uses specified in subsection (a) of that specified in this Section if the applicant demonstrates that use of the coal-combustion waste satisfies all of the following criteria: the use will not cause, threaten, or allow the discharge of any contaminant into the environment; the use will otherwise protect human health and safety and the environment; and the use constitutes a legitimate use of the coal-combustion waste as an ingredient or raw material that is an effective substitute for an analogous ingredient or raw material if the use has been shown to have no adverse environmental impact greater than the beneficial uses specified, in consultation with the Department of Mines and Minerals, the Illinois Clean Coal Institute, the Department of Transportation, and such other agencies as may be appropriate.

The Agency's beneficial use determinations may allow the uses set forth in items (a)(3)(A) and (a)(7) through (a)(9) of this Section without the CCB being subject to the restrictions set forth in subdivisions (a-5)(B) and (a-5)(E) of this Section.

Within 90 days after the receipt of an application for a beneficial use determination under this subsection (b), the Agency shall, in writing, approve, disapprove, or approve with conditions the beneficial use. Any disapproval or approval with conditions shall include the Agency's reasons for the disapproval or conditions. Failure of the Agency to issue a decision within 90 days shall constitute disapproval of the beneficial use request. These beneficial use determinations are subject to review under Section 40 of this Act.

Any approval of a beneficial use under this subsection (b) shall become effective upon the date of the Agency's written decision and remain in effect for a period of 5 years. If an applicant desires to continue a beneficial use after the expiration of the 5-year period, the applicant must submit an application for renewal no later than 90 days prior to the expiration. The beneficial use approval shall be automatically extended unless denied by the Agency in writing with the Agency's reasons for disapproval, or unless the Agency has requested an extension for review, in which case the use will continue to be allowed until an Agency determination is made.

Coal-combustion waste for which a beneficial use is approved pursuant to this subsection (b) shall be considered CCB during the effective period of the approval, as long as it is used in accordance with the approval and any conditions.

The Board shall adopt rules establishing standards and procedures for the Agency's issuance of beneficial use determinations under this subsection (b). The Board rules may also, but are not required to, include standards and procedures for the revocation of the beneficial use determinations. Prior to the effective date of Board rules adopted under this subsection (b), the Agency is authorized to make beneficial use determinations in accordance with this subsection (b).

The Agency is authorized to prepare and distribute guidance documents relating to its administration of this Section. Guidance documents prepared under this subsection are not rules for the purposes of the Illinois Administrative Procedure Act.

(Source: P.A. 92-574, eff. 6-26-02.)