HB4172 Engrossed LRB095 14143 CMK 40004 b

1     AN ACT concerning safety.
 
2     Be it enacted by the People of the State of Illinois,
3 represented in the General Assembly:
 
4     Section 5. The Environmental Protection Act is amended by
5 changing Section 3.135 as follows:
 
6     (415 ILCS 5/3.135)  (was 415 ILCS 5/3.94)
7     Sec. 3.135. Coal combustion by-product; CCB.
8     (a) "Coal combustion by-product" (CCB) means coal
9 combustion waste when used beneficially in any of the following
10 ways:
11         (1) The extraction or recovery of material compounds
12     contained within CCB.
13         (2) The use of CCB as a raw ingredient or mineral
14     filler in the manufacture of the following commercial
15     products: cement; concrete and concrete mortars;
16     cementious products including block, pipe and
17     precast/prestressed components; asphalt or cementious
18     roofing products; plastic products including pipes and
19     fittings; paints and metal alloys; kiln fired products
20     including bricks, blocks, and tiles; abrasive media;
21     gypsum wallboard; asphaltic concrete, or asphalt based
22     paving material.
23         (3) CCB used (A) in accordance with the Illinois

 

 

HB4172 Engrossed - 2 - LRB095 14143 CMK 40004 b

1     Department of Transportation ("IDOT") standard
2     specifications and subsection (a-5) of this Section or (B)
3     under the approval of the Department of Transportation for
4     IDOT projects.
5         (4) Bottom ash used as antiskid material, athletic
6     tracks, or foot paths.
7         (5) Use in the stabilization or modification of soils
8     providing the CCB meets the IDOT specifications for soil
9     modifiers.
10         (6) CCB used as a functionally equivalent substitute
11     for agricultural lime as a soil conditioner.
12         (7) Bottom ash used in non-IDOT pavement sub-base or
13     base, pipe bedding, or foundation backfill.
14         (8) Structural fill, when used in an engineered
15     application or combined with cement, sand, or water to
16     produce a controlled strength fill material and covered
17     with 12 inches of soil, within 30 days after the final
18     placement and completion of the structural fill project or
19     if the project becomes inactive for more than 90 days,
20     unless infiltration is prevented by the material itself or
21     other suitable cover material. CCB may be used under this
22     item (8) only if the structural fill is located no less
23     than 250 feet from any active or operating downgradient
24     well being used as a residential or municipal potable water
25     source.
26         Within 3 months after notification to the Agency under

 

 

HB4172 Engrossed - 3 - LRB095 14143 CMK 40004 b

1     item (C) of subsection (a-5) of this Section, the Agency
2     must inspect the structural fill project to ensure that the
3     cover requirements of this item (8) are satisfied for each
4     project involving the use of coal combustion waste as
5     structural fill.
6         (9) Mine subsidence, mine fire control, mine sealing,
7     and mine reclamation.
8     (a-5) Except to the extent that the uses are otherwise
9 authorized by law without such restrictions, the uses specified
10 in items (a)(3)(A) and (a)(7) through (9) shall be subject to
11 the following conditions:
12         (A) CCB shall not have been mixed with hazardous waste
13     prior to use.
14         (B) CCB shall not exceed Class I Groundwater Standards
15     for metals when tested utilizing test method ASTM D3987-85.
16     The sample or samples tested shall be representative of the
17     CCB being considered for use.
18         (C) Unless otherwise exempted, users of CCB for the
19     purposes described in items (a)(3)(A) and (a)(7) through
20     (9) of this Section shall provide notification to the
21     Agency for each project utilizing CCB documenting the
22     quantity of CCB utilized and certification of compliance
23     with conditions (A) and (B) of this subsection.
24     Notification shall not be required for users of CCB for
25     purposes described in items (a)(1), (a)(2), (a)(3)(B),
26     (a)(4), (a)(5) and (a)(6) of this Section, or as required

 

 

HB4172 Engrossed - 4 - LRB095 14143 CMK 40004 b

1     specifically under a beneficial use determination as
2     provided under this Section, or pavement base, parking lot
3     base, or building base projects utilizing less than 10,000
4     tons, flowable fill/grout projects utilizing less than
5     1,000 cubic yards or other applications utilizing less than
6     100 tons.
7         (D) Fly ash shall be managed in a manner that minimizes
8     the generation of airborne particles and dust using
9     techniques such as moisture conditioning, granulating,
10     inground application, or other demonstrated method.
11         (E) CCB is not to be accumulated speculatively. CCB is
12     not accumulated speculatively if during the calendar year,
13     the CCB used is equal to 75% of the CCB by weight or volume
14     accumulated at the beginning of the period.
15         (F) CCB shall include any prescribed mixture of fly
16     ash, bottom ash, boiler slag, flue gas desulfurization
17     scrubber sludge, fluidized bed combustion ash, and stoker
18     boiler ash and shall be tested as intended for use.
19     (b) To encourage and promote the utilization of CCB in
20 productive and beneficial applications, upon request by the
21 applicant, the Agency shall make a written beneficial use
22 determination that coal-combustion waste is CCB when used in a
23 manner other than those uses specified in subsection (a) of
24 this Section if the applicant demonstrates that use of the
25 coal-combustion waste satisfies all of the following criteria:
26 the use will not cause, threaten, or allow the discharge of any

 

 

HB4172 Engrossed - 5 - LRB095 14143 CMK 40004 b

1 contaminant into the environment; the use will otherwise
2 protect human health and safety and the environment; and the
3 use constitutes a legitimate use of the coal-combustion waste
4 as an ingredient or raw material that is an effective
5 substitute for an analogous ingredient or raw material.
6     Notwithstanding the criteria set forth in this subsection
7 (b), the The Agency's beneficial use determinations may allow
8 the uses set forth in items (a)(3)(A) and (a)(7) through (9) of
9 this Section without the CCB being subject to the restrictions
10 set forth in subdivisions (a-5)(B) and (a-5)(E) of this
11 Section.
12     Within 90 days after the receipt of an application for a
13 beneficial use determination under this subsection (b), the
14 Agency shall, in writing, approve, disapprove, or approve with
15 conditions the beneficial use. Any disapproval or approval with
16 conditions shall include the Agency's reasons for the
17 disapproval or conditions. Failure of the Agency to issue a
18 decision within 90 days shall constitute disapproval of the
19 beneficial use request. These beneficial use determinations
20 are subject to review under Section 40 of this Act.
21     Any approval of a beneficial use under this subsection (b)
22 shall become effective upon the date of the Agency's written
23 decision and remain in effect for a period of 5 years. If an
24 applicant desires to continue a beneficial use after the
25 expiration of the 5-year period, the applicant must submit an
26 application for renewal no later than 90 days prior to the

 

 

HB4172 Engrossed - 6 - LRB095 14143 CMK 40004 b

1 expiration. The beneficial use approval shall be automatically
2 extended unless denied by the Agency in writing with the
3 Agency's reasons for disapproval, or unless the Agency has
4 requested an extension for review, in which case the use will
5 continue to be allowed until an Agency determination is made.
6     Coal-combustion waste for which a beneficial use is
7 approved pursuant to this subsection (b) shall be considered
8 CCB during the effective period of the approval, and the
9 continued approval upon renewal may not be denied by the Agency
10 as long as it is used in accordance with the approval and any
11 conditions. Any determination under this subsection (b) is
12 subject to review under Section 40 of this Act.
13     Notwithstanding the other provisions of this subsection
14 (b), written beneficial use determination applications for the
15 use of CCB at sites governed by the federal Surface Mining
16 Control and Reclamation Act of 1977 (P.L. 95-87) or the rules
17 and regulations thereunder, or by any law or rule or regulation
18 adopted by the State of Illinois pursuant thereto, shall be
19 reviewed and approved by the Office of Mines and Minerals
20 within the Department of Natural Resources pursuant to 62 Ill.
21 Adm. Code 1700-1850. Further, appeals of those
22 determinations shall be made pursuant to the Illinois
23 Administrative Review Law.
24     The Board shall adopt rules establishing standards and
25 procedures for the Agency's issuance of beneficial use
26 determinations under this subsection (b). The Board rules may

 

 

HB4172 Engrossed - 7 - LRB095 14143 CMK 40004 b

1 also, but are not required to, include standards and procedures
2 for the revocation of the beneficial use determinations. Prior
3 to the effective date of Board rules adopted under this
4 subsection (b), the Agency is authorized to make beneficial use
5 determinations in accordance with this subsection (b).
6     Notwithstanding any other rulemaking authority that may
7 exist, neither the Governor nor any agency or agency head under
8 the jurisdiction of the Governor shall make or promulgate rules
9 to implement or enforce the provisions of this amendatory Act
10 of the 95th General Assembly. Nothing contained in this
11 amendatory Act of the 95th General Assembly shall be
12 interpreted to grant rulemaking authority under any other
13 Illinois statute where such authority is not otherwise
14 explicitly given. For the purposes of this paragraph, "rules"
15 is given the meaning contained in Section 1-70 of the Illinois
16 Administrative Procedure Act, and "agency" and "agency head"
17 are given the meanings contained in Sections 1-20 and 1-25 of
18 the Illinois Administrative Procedure Act to the extent that
19 such definitions apply to agencies or agency heads under the
20 jurisdiction of the Governor.
21     No later than January 1, 2009, the Governor, in
22 coordination with the Agency and the Board, must propose rules
23 to the General Assembly by filing them with the Clerk of the
24 House and the Secretary of the Senate and request that the
25 General Assembly authorize such rulemaking by law, enact those
26 proposed rules into law, or take any other appropriate action

 

 

HB4172 Engrossed - 8 - LRB095 14143 CMK 40004 b

1 in the General Assembly's discretion. The proposed rules must
2 concern the use of CCB under item (8) of subsection (a). The
3 proposed rules must include specific guidelines for the use of
4 CCB as structural fill and a site-approval process. The
5 proposed rules must specify that agency approval is not
6 required for a structural fill project if that project uses
7 less than 10,000 tons of CCB material or if the fill material
8 meets the ASTM D3987-85 standards for Class 1 Groundwater. The
9 proposed rules for a site-approval process must include, along
10 with other permits that may be required, (i) specific
11 timeframes for Agency approval and (ii) informal consultation
12 with the Department of Natural Resources on whether the
13 structural fill project will harm any endangered species.
14     The Agency is authorized to prepare and distribute guidance
15 documents relating to its administration of this Section.
16 Guidance documents prepared under this subsection are not rules
17 for the purposes of the Illinois Administrative Procedure Act.
18     (c) In addition to the other penalties and remedies
19 provided in this Act, any person harmed by a violation of item
20 (8) of subsection (a) of this Section may bring a civil action
21 in the circuit court of the county of that person's residence
22 for damages or other appropriate legal or equitable remedies
23 against the violator.
24 (Source: P.A. 94-66, eff. 1-1-06.)